大學學報(理學版)第31卷第6期Journal of Zhejiang University(Science Editionhttp://www.journals,zju.edu.cn/sci石油瀝青質的熱解動力學研究董喜貴1,雷群芳',俞慶森(1,浙江大學化學系,浙江杭州310027;2.大慶采油二廠,黑龍江大慶163414)摘要從國內外5種不同原油中分高提取正已統瀝青質,分別進行10,15,20,25C·m四個加熱進率下的熱重分析(TGA),關聯系列不同揮發度下的瀝青質裂解活化能和指前因子等動力學參數.活化能和指前因子隨揮發度變化而變化,指前因子的對數與活化能之間有很好的直線關系,顯示出良好的補償效應,說明瀝青質裂解反應由許多具有不同動力學參數的平行反應組成,用活化能分布模型計算了活化能和指前因子的分布函數,該模型能較好地表達瀝青質的熱裂解特征關鍵詞:瀝青質;裂解;動力學;熱重分析中圖分類號:O642.4;TE622.1文獻標識碼:A文章編號:1008-9497(2004)06-652-05DONG Xi-gui, LEI Qun-fang, YU Qing-sen'(I. Department of Chemistry, Zhejiang University, Hangzhou310027, China; 2. No, 2 Oil Production Company, Daging Oil Field Co. Ltd, Daqing 163414, China)Thermal pyrolysis kinetics of asphaltenes from several crude oils. Journal of Zhejiang University(Science Edition)2004,31(6):652~656Abstract: Five kinds of asphaltenes were extracted from different crude oils by n-hexane precipitation. Thermogravimetric analysis (TGA) was carried out for these asphaltenes with four different heating rate of 10, 15, 20 and25 C. min, respectively. The kinetic parameters, active energy (E)and preexponential factor (ko), of thermalpyrolysis for asphaltenes at different conversion levels were correlated from the experimental TG data. The conversion-dependent E and ko values were obtained. The compensation effect is clearly observed from a straight lineof the plot of In(ko)versus E. It follows that many parallel reactions with different rate parameters occur simultaneously during the thermal pyrolysis of asphaltenes. The distribution functions, f(E)and ko(E), were then estmated satisfactorily by the distributed activation energy model (DAEM)Key words: asphaltene; pyrolysis; kinetics; thermogravimetric analysis (TGA): distributed activation energymodel (DAEM)瀝青質是石油中的重要化學組分,它是指不溶度的燃燒或注人水蒸氣,增加重油的流動性和溶解于低碳正構烷烴(nC5~nC8)而溶于苯、甲苯等溶能力,以提高重質油藏的采出效果,但存在熱損失劑的一類物質,是石油中分子量最大、極性最強的組大、瀝青質等熱敏性物質沉積等問題,甚至存在轉變分.石油中,瀝青質膠質烴構成一個連續的動態穩成無用的焦炭的現象.考慮到瀝青質在原油開采與定系統[2,類似于膠體系統瀝青質是該系統的核加工中的作用和影響探討瀝青質的物理化學性質心,石油烴為分散介質,膠質是穩定化劑當該系統和熱解動力學具有實際意義,因?yàn)r青質組成和結構受到破壞瀝青質發生聚集沉淀,給油藏開發、原油十分復雜,雖然已經開展了許多研究工作,但是仍存運輸和后處理帶來困難;瀝青質也是原油加工中主在不少問題和爭議.目前,關于瀝青質的化學組成、要的生焦母體,其熱穩定性與結焦、管線堵塞等有害結構和性質研究是油田化學和石油化工領域的熱點現象密切相關1.油田開采和原油加工的許多新技課題之一9,本文在提取幾種原油瀝青質后,通過術都需要加強對瀝青質的認識,比如:重油和油頁巖熱重析甘抽珞寧性獲得活化能、指前因開采中的熱力開采工藝,通過在油層內進行一定程子以YHE中國煤化工力學參數CNMHG收稿日期:2004-0422基金項目:浙江省分析測試基金資助項目(03101)作者簡介:董喜貴(1964—),男,博士生,主要從事石油化學和物理化學研究第6期董喜貴,等:石油瀝青質的熱解動力學研究6531實驗部分1.3熱重分析采用德國產 NETZSCH STA409PG/PC型熱重1.1瀝青質的提取分析系統程序升溫速率為10、15、20、25C·min-,選擇伊朗(YL)、俄羅斯(RU)和我國遼河最終實驗溫度為800C.熱裂解在高純氮?dú)猸h(huán)境中進H)、新疆(XJ)、華北(HB)等5種原油,原料油取行,氮?dú)饬髁靠刂圃?0mL·min-,試樣用量6~8自國內有關煉油廠.以正已烷為溶劑提取瀝青質提mg.熱重(TG)及微分熱重(DTG)數據由軟件自動取步驟:準確稱取一定原料油,放于磨口錐形瓶中,采集h左右石,冷卻后放置暗處約8b左右用定量濾過2結果與討論濾出沉淀物,用兩層濾紙包好,放于索氏提取器中進2.1基本性質行抽提,至抽提液無色為止,取出濾紙,刮下沉淀物,瀝青質的元素組成等基本性質列于表1.瀝青在蒸空烘箱中除去溶劑,得到有金屬光澤的瀝青質.質主要有碳、氫兩種元素組成,質量分?jǐn)?shù)達到90%1.2瀝青質的基本性質測定~93%左右;HC原子比在1~1.3左右;S、N、O等采用 Carlo erba ea1110型元素分析儀測定瀝雜原子的質量分?jǐn)?shù)可達6.4%~9.6%用蒸氣壓滲青質的碳(C)氫(H)氮(N)元素的質量分?jǐn)?shù),采用透(VPO法測定的瀝青質相對分子質量為3300~氧彈法測定硫(S),差減得到氧(O).采用蒸氣壓滲透5600,不同瀝青質的相對分子質量之間差別較大(VPO)法測定相對分子質量,苯作溶劑,實驗溫度45NMR測得不同種類H和C的質量分?jǐn)?shù),其中HC,用光譜純聯苯甲酰和菲進行標定.采用 Bruker為與芳香環上碳原子相連接的氫原子,H為與烷碳Avance dmX500型超導核磁共振波譜儀測定H原子相連接的氫原子,C為芳碳原子,C為烷碳NMR和CNMR譜,CDCl3為溶劑,TMS為內標原子表1瀝青質的基本性質Table 1 Fundamental properties of asphaltenes%O%Cal5500.11860.88140.42410.5759RU85.597.521.053.682.247300.12890.87110.44830.5517LH84.387.971.783.202.756400.10780.89220.36490.6351XJ85.307.652.033.651.433800.12850.87150.47750.5225HB85.168.0.08010,39700.60302.2熱解動力學由實驗結果可知,瀝青質在惰性氣氛下加熱,發2.2.1熱裂解過程分析生明顯的物理和化學變化,熱解過程主要發生在以俄羅斯原油瀝青質的熱裂解為例,TG和400~520C范圍內,約占整個失重質量分?jǐn)?shù)的DTG曲線如圖1所示,裂解轉化率(v/V)與溫度80%,小于400C,失重質量分?jǐn)?shù)大約為10%,大于的關系如圖2所示,其中v為某時刻的揮發率,V520C,失重質量分?jǐn)?shù)大約為20%為時間趨于無窮時的最終揮發率,特定轉化率所對應的轉化溫度列于表2,其它瀝青質類似△10℃min℃℃TG中國煤化工CNMHG率與溫度的關系圖1俄羅斯原油瀝青質熱解的TG-DTG曲線Fig 2 Conversion ratio against temperature of pyrolyFig 1 TG-DTG curve of pyrolysis of asphaltenes fromsis of asphaltenes from Russia crude oilRussia crude oi654浙江大學學報(理學版)第31卷表2俄羅斯原油瀝青質熱解過程特定轉化率者用活化能分布模型來處理瀝青質的熱裂解動力對應的溫度學.主要包括以下幾個步驟:(a)由熱重實驗獲得至Table 2 Temperatures at selected conversion levels of少三個加熱速率β下的V/V~T關系;(b)選擇pyrolysis of asphaltenes from Russia crude oil系列固定的V/v·值,分別計算不同B下的對應溫v/V度T和B/T的值;(c)給定V/V·值時,以ln(B/T2)10C·min-115C·min-120c·min-125C·min對1/T作圖,由式(2)的直線斜率和截距計算活化0.1392396.1399.5403.80.2429.3441.2能E和指前因子k;(d)以V/V·對E作圖,根據445.1148.9452.7456.9V/v·~E函數關系求得分布函數f(E);(e)關聯468.k。和E的關系,求得k(E)0.5466.5470.3474.2478.2圖3給出俄羅斯原油瀝青質熱裂解過程的476.4480.5484.4488.3ln(B/T2)對1/T關系,由這些直線的斜率和截距計算相應活化能E和指前因子kV/V‘與E的關系13.1519.3521.7示于圖4,由圖4中曲線求得的活化能分布函數2.2.2動力學計算f(E),見圖5對于熱重動力學處理已經有不少報道,主要有Friedman法等微分模型和 Coats- Redfern法、ChenNutt祛法等積分模型1o,還有根據DTG峰溫計算-14.0的 Ozawa法、 Kissinger法等,以及多升溫速率等14.2溫法12等.對于純物質,可以假設全濃度范圍內滿-144足相同反應機理函數13來關聯動力學參數,但有時會得出模棱兩可的結論.特別是對于組成非常復雜Vp=0.06的煤、干酪根、瀝青、生物質等系統,與純物質一樣用單一反應模型來描述存在嚴重缺陷419,一般難以-15.2o20s0oks010000達到滿意的關聯效果,必須建立新的處理方法有1251.301.351.401.451.50L.551.601000/T的10分若干個溫度段,再分別加以關聯求出各段動力學參數,但很難得到準確結果[;有的10假圖3俄羅斯原油瀝青質熱裂解過程的ln(P/T2)~1T關系設裂解反應由無限多平行反應組成,且它們的指前Fig 3 Polts of In(B/T)versus 1/T at selected V/V因子相同,活化能可以用 Gaussian分布函數描述values pyrolysis of asphaltenes from RussiaMiura等7-10通過仔細對比和研究,認為對于燃料crude oil等復雜組分物質的熱裂解,應當采用更一般的活化能分布模型( Distributed Activation Energy Model,DAEM).它假設復雜組分系統的熱裂解由許多具0.8幸有不同動力學參數的不可逆一級平行反應組成,且有關系:1-/V=」。xp(-kcdr/(E)dE,0.4其中,r為反應時間,k為指前因子,R為氣體常數E為活化能,f(E)為歸一化的活化能分布函數.經0100200300400500600700E/(kJ mol)過適當近似和數學推導,還得到中國煤化工koRV~E關系E|+0.6075C N MH Gfor pyrolysis of其中,β為加熱速率.該模型用于煤的熱裂解計算取haltenes得良好效果,但尚未見用于瀝青質的報道.瀝青質的由圖5可見,不同來源原油瀝青質的熱裂解活熱裂解動力學的研究尚處于探索性階段.這里,作化能及其分布差別較大,YL和HB的活化能分布第6期董喜貴,等:石油瀝青質的熱解動力學研究655較寬,而LH和XJ的活化能分布在很窄的范圍內;根據 Arrhenius方程和過渡狀態理論,有YL、RU、LH、XJ和HB的活化能峰值Emx分別為k=k(3)500、345、270、350、220kJ·mol-,它們大體可以代表瀝青質熱裂解的平均活化能.可以注意到,Em與k=kBrexpexpRT瀝青質中雜原子(特別是硫元素)質量分?jǐn)?shù)有相似的△S遞變趨勢,說明雜原子對瀝青質結構的穩定性可能-exp起到重要的作用其中,kB為 Boltzmann常數,h為 Planck常數,△S為活化熵變.瀝青質在熱裂解初期,首先以低活化能LH的反應途徑進行降解,主要是雜原子化學鍵和一些0.05活性基團的優先斷裂,此時瀝青質分子之間活性基團的相互作用使得△S·為較大的負值,表現為活化能E較低時指前因子k也較小.隨著分子中弱化學0.03鍵不斷破壞,活性基團不斷減少,瀝青質分子從較為0.02松弛的結構轉變?yōu)檩^緊密堆積的結構,分子之間的相互作用減弱,降解反應的活化能增大,瀝青質降解10015020025030035040045050055反應可能過渡到以單分子反應或準單分子反應占優E/(kJ·mol)勢,此時△S‘為較小的負值甚至可能轉變?yōu)檎?圖5活化能分布函數f(E)表現在活化能較高時k也較大.指前因子k呈指數Fig. 5 The distribution function f(E)of activation增大對反應速度常數有較大的貢獻,這在一定程度上可以補償由于活化能增大而造成的速度常數減k。與E的關系示于圖6,顯然In(k)與E呈直少.所以,n(k)與E的正相關性也可稱為補償效應線關系,且具有較好的正相關性,k(E)的關聯結果 Compensation effect )Lo:1見表3,其中R2為復相關系數,SD為標準偏差由活化能和指前因子分布函數f(E)和k(E)代人式(1),進行數值積分可以求得揮發度v/V‘,90計算結果與實驗值對比于圖2中,兩者吻合較好,說明活化能分布模型能較好地用于瀝青質的熱解動力70上◇HB學描述結論10從國內外5種不同原油中分離提取得到正己烷瀝青質,分別進行了4個不同加熱速率下的TG0100200300400500600700DTG分析.不能簡單地用單個反應來描述組成復雜圖6In(k)與E的關系的瀝青質的熱裂解動力學.用活化能分布模型計算Fig 6 Plots of In(ko) versus E了活化能和指前因子的分布函數,效果良好.不同來表3ln(k)與E的關聯結果:源的原油瀝青質的熱裂解活化能及其分布有較大差ln(k。)=A+B(E-Emx)別,指前因子與活化能之間存在明顯的補償效應Table 3 Correlation results of in(ko)against E with theorm of In(k。)=A+B(E一Emx)參考文獻( References):BR中國煤化工YL72.510.15255001.0002.06[1]PU50.330.14133450.CNMHGgregation and deposiLH38.190.15422700.996um crudes[J]. EnergyXJ52.480.13433500.9932.39HB29.910.14072200.9791.35[2] STORM DA, SHEU E Y. Characterization of collodal asphaltenic particles in heavy oil[J]. Fuel, 1995浙江大學學報(理學版)31卷74(8):1140-1145lU Rong-zu, SHI Qi-zhen. Kinetics for Therma[3]孫海云,郭永勝,方文軍,等.吸熱型碳?xì)淙剂蠠岚捕ㄐ訟nalysis[M]. Beijing: Science Press, 2001. 108.研究[].浙江大學學報(理學版),2004,31(2):167[12]張偉南,袁譽洪,李麗清,等.二水草酸鋅脫水的熱分解動力學研究[].物理化學學報,2004,20(1):33SUN Hai-yun, GUO Yong-sheng, FANG Wen-junt al. Study on thermal stability of endothermic hyZHANG WeiYUAN Yu-hong, LI L.i-ging,etdrocarbon fuels[J]. J of Zhejiang University (ScienceEdition),2004.31(2):167-170dehydration of zinc oxalate dihydrate [J]. Acta Phys[4]王宗賢,張宏玉,郭愛軍,等.渣油中瀝青質的締合狀況Chim Sin,2004,20(1):33-37與熱生焦趨勢研究[J].石油學報(石油加工),2000,[13]GAOX, POLLIMORE D. a kinetic study of the16(4):60-64thermal decomposition of magnes(ll)oxalate dihyWANG Zong-xian, ZHANG Hong-yu, GUO Ai-jundonate[J]. Thermochimica Acta, 1993, 215:4et al. A study of association of asphaltene moleculesin vacuum residues[J]. Acta Petrolei Sinica([14]朱學棟,朱子彬,張成芳.煤熱失重動力學的研兗Petroleum Processing Section), 2000, 16(4): 60-64[J].高?；瘜W(xué)工程學報,1999,13(3):223-228[5] XU Ying-nian, YOSHIKATA K, STRAUSZ O PZHU Xue-dong, ZHU Zi-bin, ZHANG Cheng-fang.Characterization of Athabasca asphaltenes by smallStudy of the coal pyrolytic kinetics by thermogram-angle X-ray scattering [J]. Fuel,1995,74(7):960try[J]. J of Chemical Engineering of Chinese Universities,1999,13(3):223-228.[6] VICTOROV A l FIROOZABADI A Thermodynamic [15] BRAUN R L, BURNHAM AK, REYNOLDS J Gmicellization model of asphaltene precipitation fromet al. Pyrolysis kinetics for L acustrine and Marinepetroleum fluids [J]. AIChE J, 1996.42(6):1753-source rocks by programmed micropyrolysis [J].En1764rgy& Fuels,1991,5:192-204[7] TAYLOR S E. The electrodeposition of asphaltenes [16] LAKSHMANAN CC, BENNETT M L, WHITEnd implications for asphaltene structure and stabilityN. Implications of multiplicity in kinetic parametersin crude and residual oils[J]. Fuel, 1998, 77(8):821to petroleum exploration distributed activation ener-828gy models[J]. Energy &Fuels, 1991,5:110-117[8]廖澤文,耿安松,油藏開發中瀝青質的研究進展[].科17] MIURA K. A new and simple method to estimate學通報,199944(19):2018-2024.f(E)and k(E)in the distributed activation energyLIAO Ze-wen, GENG An-song. Development of themodel from three sets of experimental data[].Enerstudy on asphaltene in the oil reservoir exploitation[]. Science Bulletin,1999,44(19):2018-2024.8)8y& Fuels,199,9:302-307[18] MAKI T, TAKATSUNO A, MIURA K. Analysis[9]廖澤文,耿安松.瀝青質熱解動力學研究及其應用初探of pyrolysis reactions of various coals including ar[].自然科學進展,2000,10(2):183-189gonne premium coals using a new distributed activa-LIAO Ze-wen, GENG An-song. Study on the thermaltion energy model [J]. Energy Fuels, 1997. 11:pyrolysis kinetics of asphaltene and its application[J].972-977Progress of Natural Science, 2000, 10(2): 183-189[19 MIURA K, MAKI T A simple method for estimat[10] YUE C, WATKINSON A P. Pyrolysis of pitch [J]ing f(E) and ko(E)in the distributed activation en-Fuel,1998,77:695-711ergy model [J]. Energy &Fuels,1998, 12:864-[11]胡榮祖,史啟楨.熱分析動力學[M].北京:科學出版社,2001.108.(責任編輯涂紅)中國煤化工CNMHG